Patient-Warming Systems May Affect OR Ventilation, Study Suggests

Article

Forced-air systems used to keep patients warm during surgery may affect the performance of operating room (OR) ventilation systemspotentially increasing exposure to airborne contaminants, reports a study in the August issue of Anesthesia & Analgesia, the journal of the International Anesthesia Research Society (IARS). By comparison, conductive warming systems don't disrupt ventilation airflows over the surgical site, according to the report by Dr. Kumar G. Belani of University of Minnesota and colleagues. But an accompanying editorial notes that there's not yet enough evidence to change current practice with regard to patient warming in the OR.

The researchers compared the effects of two different types of patient warming systems on airflow in the OR. Modern ORs use "sophisticated ventilation systems to create localized zones of highly filtered air over the surgical site," according to Dr Belani and coauthors.

For the experimental study, the researchers set up an OR as for knee replacement surgery, using a mannequin. They then assessed the performance of the OR ventilation system using "neutrally buoyant detergent bubbles," which made it possible to visualize airflow patterns under different conditions.

Airflow was compared using a forced-air warming system, which distributes heated air under the surgical drapes and over the patient; and a conductive warming system (such as heated water blankets), which applies direct heat to the patient's skin.

Forced-air warming "generated hot air convection currents that mobilized bubbles over the anesthesia site and into the surgical site," Belani and colleagues write. The average "bubble count" in the simulated surgical field was more than 100 with the forced-air warmer, compared to about 0.50 with a conductive warming system.

The convection currents created by the forced-air system drew air from under the surgical drapes and into the surgical site. The concern is that this could mobilize bacteria or other contaminants from nonsterile areas, or interfere with the ventilation system's ability to clear contaminants from the surgical site.

The use of " downward displacement" OR ventilation systems had previously been shown to reduce exposure to microbes and infection rates during certain types of surgery. But more recent studies have found no reduction in infection rates. The new study was designed to test whether forced-air warming systemsa relatively recent introduction to ORscould be affecting ventilation performance.

The results suggest that forced-air patient warming systems may indeed affect airflows in the OR, potentially increasing exposure to bacteria and other contaminants during surgery. Belani and coauthors conclude, "These findings warrant future research into the effects of forced air warming excess heat on clinical outcomes during contamination-sensitive surgery."

In the editorial, Drs. Charles Weissman and W. Bosseau Murray note that the findings provide only indirect evidence of potential infection risk, in a simulated setting. That's in contrast to the known benefits of preventing drops in body temperature during surgery. Pending further research, Weissman and Murray write, "[T]he prudent coursemight be to continue with the presently proven successful warming therapies, but keep an open mind about the possible future need to change practice."

Related Videos
Patient Safety: Infection Control Today's Trending Topic for March
Infection Control Today® (ICT®) talks with John Kimsey, vice president of processing optimization and customer success for Steris.
Picture at AORN’s International Surgical Conference & Expo 2024
An eye instrument holding an intraocular lens for cataract surgery. How to clean and sterilize it appropriately?   (Adobe Stock 417326809By Mohammed)
Photo of a model operating room. (Photo courtesy of Indigo-Clean and Kenall Manufacturing)
Washington, USA, US Treasury Department and Inspector General Office.    (Adobe Stock File 210945332 by Brian_Kinney)
A plasmid is a small circular DNA molecule found in bacteria and some other microscopic organisms. (Adobe Stock 522876298 by Love Employee)
Peter B. Graves, BSN, RN, CNOR, independent perioperative, consultant, speaker, and writer, Clinical Solution, LLC, Corinth, Texas; Maureen P. Spencer, M.Ed, BSN, RN, CIC, FAPIC, infection preventionist consultant, Infection Preventionist Consultants, Halifax, Massachusetts; Lena Camperlengo, DrPH, MPH, RN, Senior Director, Premier, Inc, Ocala, Florida.
Surgery (Adobe Stock, unknown)
Related Content